Product ID:JP-4 TURBINE FUEL,AVIATION
MSDS Date:01/01/1985
FSC:9130
NIIN:00-273-2380
MSDS Number: BDRZK

Emergency Phone: 606-324-1133

Info Phone: 606-324-1133

Cage: 81355

Telephone: 800-622-6846

Cage: 81355

ALIPHATIC PETROLEUM HYDROCARBONS (NIOSH REC TLV OF 350

Fraction By Weight: 60%

ACGIH TLV: 500 PPM (MFR)

AROMATIC PETROLEUM HYDROCARBONS(NIOSH REC TLV OF 100

ACGIH TLV: 100 PPM (MFR)

Effects of Overexposure:EYE/SKIN IRRIT, DERMATITIS.INHAL: HEADACHE,
VERTIGO,WEAKNESS,NAUSEA, UNCONSCIOUSNESS,ASPHYXIATION

First Aid:SKIN:WASH W/SOAP & WATER. REMOVE CONTAMINATED
CLOTHING/LAUNDER BEFORE REUSE. EYE: FLUSH W/WATER.INHAL:REMOVE TO
FRESH AIR,GIVE O*2.IF BREATHING STOPPED,GIVE ARTIF. RESPIRATION.
INGEST: DO NOT INDUCE V OMITING; KEEP QUIET, GET MEDICAL ATTENTION.

Flash Point:LESS THAN 73 F
Lower Limits:0.8
Extinguishing Media:DRY CHEMICAL,CO*2, REGULAR FOAM. WATER IS NOT
RECOMMENDED.
Fire Fighting Procedures:SCBA W/FULL FACEPIECE IN PRSSURE-DEMAND (POS.
PRESS) MODE.
Unusual Fire/Explosion Hazard:DENSE VAPORS MAY TRAVEL ALONG GROUND &
FLASH/IGNITE AT REMOTE SOURCES OF HEAT, SPARKS OR OPEN FLAME.

Spill Release Procedures:ELIMINATE IGNITION SOURCES, VENTILATE &
EVACUATE AREA, WEAR PROTECTIVE EQUIP. STOP SOURCE, IF POSSIBLE &
DYKE TO CONTAIN. PUMP TO SALVAGE TANK. ABSORB RESIDUAL LIQ W/
VERMICULITE OR OTHER INERT MATL. STORE IN CLOSED DRUMS UNTIL
DISPOSAL.

Handling and Storage Precautions:DO NOT USE OR STORE NEAR FLAME,SPARKS
OR HOT SURFACES. KEEP CONTAINERS CLOSED.DO NOT WELD CUT OR DRILL ON
OR NEAR CONTAINERS - EXPLOSION HAZARD.
Other Precautions:INGESTION MAY CAUSE GI IRRIT,NAUSEA, VOMITING &
DIARRHEA. DO NOT INDUCE VOMITING. GASTRIC LAVAGE IS PREFERRED.
ASPIRATION INTO LUNGS MAY CAUSE CHEM. PNEUMONITIS WHICH CAN BE
FATAL.

Respiratory Protection:NIOSH/MSHA-APPROVED RESP SELECT FOR EXPOSURE
CONDITIONS OF CONERN
Ventilation:SUFFICIENT MECH/GENERAL DILUTION VENT TO KEEP BELOW TLV.
Protective Gloves:NEOPRENE/BUNA-N
Eye Protection:SPLASH-PROOF GOGGLES RECM
Other Protective Equipment:WEAR IMPERVIOUS CLOTHING/BOOTS TO PREVENT
SKIN CONTACT.
Supplemental Safety and Health
CONFORMS TO MIL-T-5624L.

HCC:F2
Boiling Pt:B.P. Text:150F (INIT)
Vapor Pres:3.0
Vapor Density:>1
Spec Gravity:0.7500
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESST TO PALE AMBER LIQUID
Percent Volatiles by Volume:100.

Stability Indicator/Materials to Avoid:YES
AVOID STRONG OXIDIZERS (EG: NITRIC ACID, PERMANAGANATES, ETC
Hazardous Decomposition Products:CARBON MONOXIDE, CO*2, VARIOUS
HYDROCARBONS

Waste Disposal Methods:DEPOSIT ABSORBENT INA LANDFILL IN ACCORDANCE
WITH FEDERAL,STAE & LOCAL REGULATIONS. DO NT ALLOW LIQUID TO ENTER
WATERCOURSES OR SEWER SYSTEMS. ALL SUCH SPILLS MUST BE REPORTED TO
HIGHER AUTHORITY.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.